ELECTRICDRIVETRUCKPhotos may include optional equipment930E-4ELECTRICDRIVETRUCKSPECIFICATIONSENGINEMake and model. . . . . . . . . . . . . . . . . . . . . Komatsu SSDA16V160*Fuel. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . DieselNumber of cylinders. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 16Operating cycle. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4 cycleRated brake power**. . . . . . . . . . . 2014 kW 2,700 HP @ 1900 rpmFlywheel power***. . . . . . . . . . . . . 1902 kW 2,550 HP @ 1900 rpmWeight (wet). . . . . . . . . . . . . . . . . . . . . . . . . . . . . 9608 kg 21,182 lb
*Tier 2 emissions compliant. Tier 1 emissions engine is optional outside of North America.**Rated brake power is the output of the engine as installed in this machine, at governed rpm and with engine manufacturer’s approved fuel setting. Accessory losses includedare water pump, fuel pump and oil pump.
***Flywheel power is the rated power at the engine flywheel minus the average accessory losses. Accessories include fan and charging alternator. Rating(s) represent net engine performance in accordance with SAE J1349 conditions.
ELECTRIC DRIVEAC/DC CURRENTAlternator. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . GTA-41Dual impeller in-line blower. . . . . . . . . . . 340 m3/min 12,000 cfmControl. . . . . . . . . . . . . . . . . . . . . . . . . AC Torque Control SystemMotorized wheels*. . . . . . . . . . GDY106 Induction Traction MotorsRatio**. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 32.62:1Speed (maximum). . . . . . . . . . . . . . . . . . . . . . 64.5 km/h 40 mph
*Wheel motor application depends upon gross vehicle weight, haul road grade, haul road length, rolling resistance and other parameters. Komatsu and G.E. must analyze each job condition to assure proper application.**Optional ratios available.
TIRES AND RIMSRock service, tubeless, radial tires
Standard tire*. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 53/80 R63Taper lock, five (5) piece rim
914 mm x 1600 mm x 127 mm 36'' x 63'' x 5.0''rim assembly. Rims rated at 758 kPa 110 psicold inflation pressure.
Typical tire weight . . . . . . . . . . . . . . . . . . . . . . . .26127 kg 57,600 lb*Tires should meet application requirements for tkph/tmph, tread, compound, inflation pressure, ply rating or equivalent, etc.BODYAll-welded steel flat floor body with horizontal bolsters and full
canopy. Eyebrow,rear wheel rock ejectors,body up sling and rubbermounts on frame are standard. Pivot exhaust heating optional.
Floor sheet. . . . . . . . . . . . . . 16 mm 0.63''1379 mPa 200,000 psi
tensile strength steel (two-piece)
Front sheet. . . . . . . . . . . . . . . 9 mm 0.35'' 1379 mPa 200,000 psi
tensile strength steel
Side sheet . . . . . . . . . . . . . . . 8 mm 0.31''1379 mPa 200,000 psi
tensile strength steel
Canopy sheet . . . . . . . . . . . . . . 5 mm 0.19''690 mPa 100,000 psiStruck . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 171 m3224 yd3Standard SAE heaped 2:1. . . . . . . . . . . . . . . . . . . 211 m3276 yd3Standard Komatsu body weight . . . . . . . . . . . .30362 kg 66,936 lb
*Komatsu must approve all bodies through a Body Application WorksheetCABAdvanced Operator Environment with integral 4-post ROPS/FOPSstructure Level 2, adjustable air suspension seat w/lumbar support andarm rests, full-size passenger seat, maximum R-value insulation, tiltand telescoping steering wheel, electric windshield wipers w/washer,tinted safety glass, power windows, Komatsu Payload WeighingSystem, 55,000 Btu/hr heater and defroster, 21,600 BTU/hr airconditioning (HFC - 134A refrigerant).
FRAMEAdvanced technology, full butt-welded box sectional ladder-typeframe with integral ROPS supports,integral front bumper, rear
tubular cross members, steel castings at all critical stress transitionzones, rugged continuous horsecollar.
Plate material . . . . . . . . . . . . . . . . . . . . . . . .482.6 mPa 70,000 psi
tensile strength steel
Casting material . . . . . . . . . . . . . . . . . . . . . .620.5 mPa 90,000 psi
tensile strength steel
Rail width . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .305 mm 12''Rail depth (minimum) . . . . . . . . . . . . . . . . . . . . . . . . . .864 mm 34''Top and bottom plate thickness . . . . . . . . . . . . . . . . .45 mm 1.77''Side plate thickness . . . . . . . . . . . . . . . . . . . . . . . . . .25 mm 0.98''Drive axle mounting . . . . . . . . . . . . . . . .Pin and spherical bushingDrive axle alignment . . . . . . . .Swing link between frame and axleBRAKING SYSTEMService brakes: oil-cooled, hydraulic-actuated, multiple disc brakes ateach wheel. Traction system wheel slip/slide control.
Max. service apply pressure . . . . . . . . . . . . . .17237 kPa 2500 psiTotal friction area per brake . . . . . . . . . . . . .97025 cm215,038 in2Emergency brakes . . . . . . . . . . . . . . . .Automatically applied prior
to hydraulic system pressure dropping below level required to meet secondary stopping requirements.
Wheel brake locks . . . . . . . . . . . . . . . . . . . . . . . . .Switch activatedParking brakes . . . . . . . . . . . . . . . . . .Multiple disc, spring-applied,hydraulically-released, dry brakes on inboard endof each wheel motor rotor shaft. Rated to hold on±15% grade at maximum gross vehicle weight.Electric dynamic retarder . . . . . . . . . . . . . .Max 4026 kW 5400 hp
Continuous 2460 kW 3300 hp
Continuously rated high-density blown grids w/retard capacity at lowspeeds and retard in reverse propulsion.
SUSPENSIONVariable rate hydro-pneumatic with integral rebound controlMax. front stroke. . . . . . . . . . . . . . . . . . . . . . . . . . 328 mm 12.92''Max. rear stroke. . . . . . . . . . . . . . . . . . . . . . . . . . . . 239 mm 9.40''Max. rear axle oscillation. . . . . . . . . . . . . . . . . . . . . . . . . . . . ±6.5°
COOLING SYSTEML&M radiator assembly, split-flow, with deaerator-type top tank.
Radiator frontal area. . . . . . . . . . . . . . . . . . . . . . . 7.02 m275.5 ft2
SERVICE CAPACITIESCooling system . . . . . . . . . . . . . . . . . . . . . . . . . . . . .594 L . . . .157 U.S. galCrankcase* . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .280 L . . . . .74 U.S. galHydraulic system . . . . . . . . . . . . . . . . . . . . . . . . . .1325 L . . . .350 U.S. galMotor gear box (each) . . . . . . . . . . . . . . . . . . . . . . . .95 L . . . . .25 U.S. galFuel . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .4542 L . . .1200 U.S. gal*Includes lube oil filters
ELECTRICDRIVETRUCK930E-4DIMENSIONS9.45 m31 0 4.14 m13 7 All dimensions are with 211 m3276 yd3body. 9.09 m29 10BodiesStandardStruck171 m3 224yd32:1 Heap211 m3 276yd3LoadingHeight*7.06 m 23'2''*Exact load height may vary due to tire make, type, and inflation pressure.HYDRAULIC SYSTEMSteering. . . . Accumulator assisted with twin double acting cylinders provide constant rate steering. Emergency steering automatically supplied by accumulator.Turning circle diameter (SAE). . . . . . . . . . . . . . . . . . . . . 29.7 m 97'7''Reservoir. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 947 L 250 U.S. galFiltration. . . . . . . . . . . . . . . . . . . . . . . . . In-line replaceable elementsSuction. . . . . . . . . . . . . . . . . . . . . . . . . . . Single, full flow, 100 meshHoist and steering. . . . . . . . . . . . . . . . . Dual, in-line, high pressureBrake component cabinet. . . . . . . . . . Above deck, easily accessible
with diagnostic test connections
Hoist. . . . . . . . . . . . . . . . Two 3-stage dual-acting outboard cylinders,
internal cushion valve, over-center dampening
Hoist times
Power-up loaded. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 21 secPower-down. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 23 secFloat-down empty. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 24 secPumps. . . . . . . . . . . . Two pumps, single package, end of alternatorHoist and brake cooling. . . . . . . . . . . . . . . . . . Tandem gear pump
with output of 1022 lpm 270 gpmat 1900 rpm
and 17237 kPa 2,500 psi
Steering and brake. . . . . . . . Pressure-compensating piston pump
with output of 246 lpm 65 gpmat 1900 rpm
and 18961 kPa 2,750 psi
System relief pressures
Hoist and brake cooling. . . . . . . . . . . . . . . . . 17237 kPa 2,500 psiSteering and brake. . . . . . . . . . . . . . . . . . . . . 27579 kPa 4,000 psiQuick disconnects standard for powering disabled truck and forsystems diagnostics.
ELECTRICAL SYSTEM4 x 8D 1450 CCA, 12 volt, in series/parallel, 220-ampere-hourbatteries, bumper-mounted with disconnect switch and lockout.
Alternator. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 24 volt, 140 ampLighting. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 24 voltCranking motors. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Two/24 volt
WEIGHT DISTRIBUTIONEmpty vehicle weight (wet, 100% fuel, no options, std. Komatsu body, std. tires)Front axle. . . . . . . . . . . . . . . 99711 kg. . . . 219,826 lbRear axle. . . . . . . . . . . . . . 110476 kg. . . . 243,557 lbTotal EVW. . . . . . . . . . . . . 210187 kg. . . . 463,383 lbGross vehicle weight (Nominal)
Front axle. . . . . . . . . . . . . . 165651 kg. . . . 365,201 lbRear axle. . . . . . . . . . . . . . 336323 kg. . . . 741,469 lbTotal. . . . . . . . . . . . . . . . . . 501974 kg. . 1,106,670 lbNominal payload*. . . . . . . . 291790 kg. . . . 643,287 lb
320 U.S. ton
33%67%47%53%
*Nominal payload is defined by Komatsu America Corp. payload policy documentation. In general, the nominal payload must be adjusted for the specific vehicle configuration and site application. The figures above are provided for basic product description
purposes. Please contact your Komatsu distributor for specific application requirements.
STANDARD EQUIPMENT•••••••••••••••••••••••••••••
Air cleaners, Donaldson SRGAir filter evacuators
Alternator (24 volt/140A)
Auto lubrication system w/ground level fill& level indicator
Batteries–4 x 8D (1450 CCA’s)Battery charging cable and socketBody over center device
Brakes: oil-cooled, multiple disc front & rear Control cabinetElectric start
Eliminator, Centinel, reserve oil tankFilters, high pressure hydraulicGate valves on hydraulic tankGround level radiator fill
Komatsu Payload Weighing System–PLM-IIIMirrors, LH flat and RH rectangular convexMud flaps
Muffled exhaust–deck-mounted
Power supply, 24 volt and 12 volt DC
Quick disconnects (hoist and diagnostics)Radiator sight gauge
Removable power module unit (radiator,engine, alternator, blower)Retard speed controlReverse retardingRock ejectors
Thermostatic fan clutch
Fast-fill fuel system (in tank and left sideremote)
Service center–LHBody impact plate
••••••
Power steering w/auto emergency steeringProtective deck handrailsPump driveline protectorRadiator fan guard
Seat belts 76 mm 3\"wide retractableSlip-resistant coating on walkways
-Low fuel
-Manual back-up lights-Parking brakes applied-Propel system not ready-Propulsion system caution-Propulsion system at rest
-Reduced propel system mode-Retard at continuous level-Retard speed control-Service brakes-Starter circuit
Indicator lights (blue)-Engine service
-KOMTRAX Plus snapshot (IM)Insulation (Max R-Value)KOMTRAX Plus
Operator seat, adjustable w/air
suspension, lumbar support and armrests
Panel lighting (adjustable)Passenger seat, full sizePayload Meter PLM IIIPower windows
Pressurized cab air system w/fan onSingle brake/retarder pedalStarter key switchSunvisor (adjustable)
Tilt & telescoping steering wheelVoltmeter (battery output)
Windshield (tinted safety plate)
Windshield wiper (dual) and washer(electric)
OPERATOR ENVIRONMENT & CONTROL•All hydraulic service brakes withemergency auto apply•Battery disconnect switch•Body up sling
•Brake lock and drive system interlock•Circuit breakers, 24 volt
•Diagonal staircase across grill, L to R•Dynamic retarding with continuous rated element grids
•Engine shutdown at ground level•Hoist propulsion interlock
•Horns (electric–front and back-up)•Integral ROPS/FOPS cab Level 2 •Maintenance and power lockout
•Parking brakes with warning light & speedapplication protection
STANDARD HIGH VISIBILITY DELUXECAB
•AC drive interface display•Air cleaner vacuum gauges•Air conditioner HFC-134A
•Alarm system warning lights (red)-Accumulator pre-charge-Auto lube pressure, low-Battery charge
-Brake/hydraulic oil temp w/alarm-Electric system fault w/alarm-IM fail
-Link energized
-Low engine oil pressure w/alarm-Low brake pressure w/alarm-No propel/retard power w/alarm-Stop engine no propel w/alarm-Steering pressure w/alarm
•AM/FM radio/CD/mp3 and XMTMcapable•Column-mounted retarder control•Digital tachometer and speedometer•Dome light
•Engine hourmeter, oil pressure gauge, coolant temperature gauge, hydraulic oiltemperature gauge
•Engine shutdown w/5 minute delay timer•Floor mat (double barrier)
•Fuel gauge in cab and on tank•Fuel low level light and buzzer•Gauges (w/backlight)•Headlight switch
•Heater and defroster (heavy-duty)•Heater switch
•High beam selector and indicator•Horn (center of steering wheel)•Indicator lights (amber):-5-minute shutdown timer-Check engine w/alarm-Circuit breaker tripped
-Coolant high temperature w/alarm-Drive system temperature w/alarm-Dump body up-Dynamic retarding
••••••••••••••••
LIGHTING
•Back-up lights–rear mount (2) halogen•Back-up lights–R and L - deck mount (2)halogen
•Brake and retard lights on top of cab•Clearance lights
•Control cabinet service light (LED)•Dynamic retarding, rear (2) halogen•Engine compartment service lights•Fog lights (2) halogen•Headlights (8) halogen•Stairway lights
•Manual back-up light, switch and indicator•Payload lights R and L (LED)•Platform lights R, L and Center•Stop & tail lights (2) (LED)•Turn signals halogen
•Under-hood service lightsOPTIONAL EQUIPMENTNote: Optional equipment may change operating weight.•••••
Body liners*
Fire extinguisher 9 kg 20 lbHeated body
Hot start engine coolant (220V 2-2500W)Hot start engine oil (220V 2-600W)
•••••
Hubodometer (miles or Kilometers)Modular Mining Systems (MMS) ready Mufflers between frame railsRadiator shutters
Reversed access ladder
•Service center–RH or dual LH/RH•Special language decals•Suspensions, cold weather
*Available factory installed or non-installed. All other options and accessories listed are available factory installed only.
AESS743-00©2007 Komatsu America Corp. Printed in USAD2(1.5M)C 2/07 (EV-3)
www.KomatsuAmerica.com
Komatsu America Corp. is an authorized licensee of Komatsu Ltd.Materials and specifications are subject to change without noticeis a registered trademark of Komatsu Ltd., Japan
因篇幅问题不能全部显示，请点此查看更多更全内容